Skip to main content
CarMonitor

Transport Canada + NRCan

2005 Chevrolet Avalanche

Everything Canada’s open data holds on this vehicle: what has been recalled, what it costs to run, and how efficient it is compared with everything else on the road.

Recalls

5

5 current

Combined

—

Fuel, a year

—

Not rated by NRCan

Recalls

Good news: Recall repairs cost you nothing. Book with any manufacturer dealer and quote the recall number — no time limit, however many owners the vehicle has had.

Heater And Defroster

Transport Canada recall 2011074 · manufacturer campaign 11046

21 February 2011

Transport Canada lists: Avalanche 2003–2006 · Silverado 2003–2007 · Suburban 2003–2006 · Tahoe 2003–2006 · and 3 more

What is wrong

On certain vehicles, the interface between the electrical terminals of the Heating, Ventilation, and Air Conditioning (HVAC) blower relay resistor module and the wiring connector (which powers the module) may be incapable of conducting higher current levels for sustained periods of operation. In addition, moisture and other contaminants (such as road de-icing materials) may enter the fresh air intake plenum and contact the internal circuit of the module or corrode the terminals. These conditions may cause the relay resistor module or wiring connector to overheat, causing various symptoms such as: the HVAC blower may not function on certain or all blower speed settings; a burning-plastic smell or smoke may be present in the vehicle, or; the HVAC blower may run continually with the ignition in the OFF position. These warning signs could, in certain instances, be leading indicators of an impending vehicle fire, which could result in property damage and/or personal injury.

What the dealer will do

Owners will be provided with additional warranty coverage for the blower motor resistor module/wiring connector overheating condition. Under this "special warranty coverage", should this condition occur within 10 years or 240,000 km from first vehicle registration, dealers will install a replacement blower motor resistor and resistor module connector.

190,310 vehicles affected in CanadaLight Truck & VanSafety TC

Fuel System

Transport Canada recall 2006195 · manufacturer campaign 06080

4 August 2006

Transport Canada lists: Avalanche 2004–2006 · Kodiak 4500 2006 · Kodiak 5500 2006 · Silverado 2004–2006 · and 5 more

What is wrong

On certain vehicles, the engine fuel rail pulse damper retainer clip may fracture, resulting in inadequate retention of the damper. If the damper comes loose, a fuel leak may result. Fuel leakage in the presence of an ignition source could result in a fire.

What the dealer will do

Dealers will replace the engine fuel rail pulse damper retainer clip.

1,485 vehicles affected in CanadaLight Truck & VanSafety Mfr

Seats And Restraints

Transport Canada recall 2005119 · manufacturer campaign 05037

25 April 2005

Transport Canada lists: Escalade 2003–2005 · Avalanche 2003–2005 · Silverado 2003–2005 · Suburban 2003–2005 · and 5 more

What is wrong

On certain vehicles, the 2nd row centre occupant seat belt routing may make it difficult to position the lap portion of the safety belt low around the hips of occupants. A lap portion of the seat belt routing that is not low and snug on the hips can allow unfavourable occupant kinetics in the event of a crash. Moreover, the higher routing allows the lap belt to ride up on an occupant's abdomen instead of fitting low around their hipbones, and therefore, can expose them to more risk of abdominal and internal organ injury.

What the dealer will do

Dealers will modify the guide loop.

73,473 vehicles affected in CanadaLight Truck & VanSafety Mfr

Lights And Instruments

Transport Canada recall 2005038 · manufacturer campaign 05023

15 February 2005

Transport Canada lists: Escalade 2005 · Avalanche 2005 · Silverado 2005 · Suburban 2005 · and 4 more

What is wrong

Certain vehicles equipped with an automatic transmission fail to comply with the requirements of CMVSS 101 - Location, identification and illumination of displays. Under certain vehicle starting conditions, the shift lever position indicator located in the instrument panel cluster may not illuminate. In subsequent vehicle start-ups, this condition may or may not occur again. If the shift lever position indicator does not illuminate, the driver may not know which gear the vehicle is in and the vehicle may move in an unintended direction, resulting in possible injury to others outside of the vehicle.

What the dealer will do

Dealers will reprogram the instrument panel cluster.

260 vehicles affected in CanadaLight Truck & VanSafety Mfr

Brakes

Transport Canada recall 2005033 · manufacturer campaign 05006

15 February 2005

Transport Canada lists: Avalanche 2004–2005 · Express 2004–2005 · Kodiak 4500 2004–2005 · Kodiak 5500 2004–2005 · and 8 more

What is wrong

On certain vehicles, the hydraulic brake booster's pressure accumulator may crack and/or separate from the Hydro-Boost assembly during normal vehicle operating conditions. If a separation occurred and the hood of the vehicle was open, fragments from the accumulator could cause injury to people in the immediate area. In addition, the presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort.

What the dealer will do

Dealers will test and, if necessary, replace the Hydro-Boost assembly.

5,014 vehicles affected in CanadaLight Truck & VanSafety Mfr

Watch this vehicle

Recall letters go to whoever owns the car on paper, which may not be you. Save your 2005 Chevrolet Avalanche and we will email you the day Transport Canada issues a new recall for it.

Only when a new recall lands. Unsubscribe in one click.

Common questions

Does the 2005 Chevrolet Avalanche have any recalls?
Transport Canada has 5 recalls on record for the 2005 Chevrolet Avalanche. Recall repairs are free at any manufacturer dealer.

Source: Transport Canada — Vehicle Recalls Database; NRCan — Fuel consumption ratings. Data current as of 30 July 2026. Running cost uses Ontario average prices (155 ¢/L, 14.5 ¢/kWh), which are hand-maintained estimates. 30,784 rated vehicles on file.